Skip to main content

One Reason Caregivers Are Wearing Trash Bags: A U.S. Firm Had to Recall 9 Million Surgical Gowns

Analysis  |  By ProPublica  
   April 04, 2020

Cardinal Health withdrew the gowns just before the pandemic because a Chinese supplier failed to sterilize them properly. The recall has created what a hospital association official called a "ripple effect."

The article was first published on Friday, April 3, 2020 in ProPublica.

By David Armstrong and Topher Sanders 

There’s an overlooked reason why hospitals treating COVID-19 patients are so short of protective gear. In January, just before the pandemic hit the United States, a key distributor recalled more than 9 million gowns produced by a Chinese supplier because they had not been properly sterilized.

“At this time, we cannot provide sterility assurances with respect to the gowns or the packs containing the gowns because of the potential for cross-contamination,” Cardinal Health wrote to customers on Jan. 15. It added, “We recognize the criticality of our gowns and procedure packs to performing surgeries, and we apologize for the challenges this supply disruption will cause.”

The recall immediately forced the canceling of some elective surgeries. It also meant that supplies of medical gowns were already low when hospitals and state governments began desperately searching for protective gear to cope with the pandemic. Most gowns are supposed to be worn once and not reused. As some doctors and nurses have resorted to covering themselves with trash bags, raincoats and hazardous materials suits bought online, many health care workers have contracted the virus, further taxing already overwhelmed hospitals.

“Demand has gone up at a time when supply was already constrained,” said Bindiya Vakil, the chief executive of Resilinc, a Milpitas, California, firm that monitors supply chain disruptions worldwide. “Coronavirus made what was already a bad situation a lot worse.”

Colin Milligan, a spokesman for the American Hospital Association, said that the group’s members continue to experience shortages of medical gowns and that the Cardinal recall “has had a ripple effect.”

A Cardinal spokeswoman said that “the supply of surgical gowns should not impact the supply of PPE,” or personal protective equipment, for health care workers because they usually wear another type of outer garment, isolation gowns, when tending to coronavirus patients.

Cardinal received approval Tuesday from the federal government to donate the 2.2 million recalled gowns that remain in its inventory to the Strategic National Stockpile for distribution as isolation gowns. Each pallet must be “labeled in with a warning that the articles are for use for non-sterile apparel purposes only,” according to the approval letter.

The company is “working around the clock to meet the needs of healthcare providers so they can safely serve the patients who depend on them,” a Cardinal spokeswoman wrote in an email.

The shortage of gowns even before the coronavirus outbreak highlights the vulnerabilities of a U.S. health care system that depends on protective equipment largely made in other countries, led by China. The quality of gowns and other gear has been a recurring problem, including a dead insect in the packaging of a Cardinal gown, complaint records show. Replacing an overseas supplier can take months, and even if a new one is found quickly, it still has to ramp up production and arrange shipping.

“Unfortunately, like others, we are learning in this crisis that overdependence on other countries as a source of cheap medical products and supplies has created a strategic vulnerability to our economy,” U.S. Trade Representative Robert Lighthizer said at a meeting Monday. “For the United States, we are encouraging diversification of supply chains and seeking to promote more manufacturing at home.”

The recall also exposes flaws in how both companies and government regulators monitor the overseas manufacturers that produce much of the country’s inventory of protective medical gear. Because surgical gowns are considered a medical device, their quality is monitored by the U.S. Food and Drug Administration, which inspects manufacturing plants every two years.

A spokeswoman for Cardinal, which is based in Dublin, Ohio, said that it has a “broad and diverse manufacturing and supplier network” that includes the U.S. and is not dependent on any one locale. Cardinal is also one of the largest prescription drug distributors in the world. It had revenues in 2019 of more than $145 billion, making it the 16th largest company in the U.S., according to Fortune.

Cardinal chief executive Mike Kaufmann told Wall Street analysts in February that the company understood “the gravity” of the recall. He said it had hired outside experts to review Cardinal’s quality assurance procedures.

The company’s board has established a special committee to review management’s actions pertaining to the recall, according to Cardinal’s website. The outside experts continue to scrutinize the company’s practices, a spokeswoman said.

Of the recalled gowns, Cardinal had already distributed almost 8 million to health care facilities; the others had not reached customers. Some had been manufactured as early as the fall of 2018, the company has said. Cardinal does not have information on how many of the gowns were used but believes a majority of them were, a spokeswoman told ProPublica. Asked if any health workers or patients were infected as a result, she said that “we continue to track and analyze complaint data.”

The FDA last inspected the problematic Chinese plant in April 2018 and did not identify any violations, an agency spokeswoman said. Manufacturers are responsible for detecting problems and reporting them to the FDA, she said, adding that the Chinese company did not report any such issues during the period covered by the recall.

The January recall was not the first time Cardinal had a problem with the supplier, which it has identified as Siyang HolyMed Products Co. in Jiangsu province on China’s coast. Cardinal disclosed in a January press release that in the spring of 2018, around the same time the FDA was inspecting the Chinese company’s manufacturing facility, the company learned that Siyang outsourced some of its production to an unqualified facility. Cardinal tested products at the time and determined there was no reason to take further action such as a recall, it said.

Then, last Dec. 10, Cardinal received a tip that Siyang was making gowns at two sites that weren’t approved by the U.S. company or registered with the FDA, a Cardinal spokeswoman said. Ten days later, an on-site investigation confirmed the tip, she said.

In a Jan. 21 letter to customers, Cardinal said it couldn’t guarantee that the gowns were sterile because Siyang made some of them at locations that “did not maintain proper environmental conditions as required by law.” They were “commingled with properly manufactured gowns,” Cardinal said.

Phone and email attempts to contact Siyang were unsuccessful. The FDA said in January that it was investigating how the gowns may have been contaminated. An agency spokeswoman did not respond to questions about the status of that investigation.

Health care workers wear gowns to protect themselves from coming in contact with blood and other bodily fluids, microorganisms and particulate material. The gowns offering the highest level of protection are sterilized. A gown that is not properly sterilized increases the risk of infection, which can be transmitted to a patient during a procedure.

Health care workers use two kinds of medical gowns. Surgical gowns, like those sold by Cardinal, provide the highest level of protection and are more heavily regulated by the FDA. Isolation gowns, which are produced in larger amounts, are not sterilized but are appropriate for many interactions with COVID-19 patients. Both are in short supply right now as hospitals are quickly burning through any gowns they have and, in some cases, using already depleted supplies of surgical gowns when isolation gowns are unavailable.

The 9.1 million gowns recalled by Cardinal likely represent about 30% of the company’s global distribution, according to Premier, a Charlotte, North Carolina, company that negotiates prices on supplies bought by more than 4,000 hospitals and health care systems. The recall “absolutely contributed to the challenges that some of our hospitals are having treating their patients,” Chaun Powell, a group vice president at Premier, said. “That put burden on the supply chain prior to COVID outbreaks, and then the COVID outbreaks only exacerbated that issue.”

In the past two years, the FDA has received several complaints about the quality of Cardinal gowns. Adverse event reports filed with the agency include accounts of inadequate and improper protective wrapping on sterile gowns, holes in gowns, and blood soaking through the protective material. The reports disclosed to the public do not name the facilities or individuals reporting the product defects. Complaints have been filed about gowns purchased from distributors other than Cardinal as well.

In 2019, a hospital reported that a sterile gown arrived from Cardinal improperly wrapped, rendering it non-sterile. “This was noticed before it was opened to the surgical field; however, had it been opened it would have contaminated the entire field,” the report said. Ten days later, another report noted another packaging defect that could have caused contamination. “This is not the first time this has happened,” according to the report. “The gowns are coming from the manufacturer this way.”

In February, after the recall, a hospital found a dead insect in the packaging of a Cardinal sterile gown, according to a report filed with the FDA. The hospital said the gown was not part of the recall. The report noted there had been previous, unconfirmed reports of hair, gum and a cigarette butt found in Cardinal products labeled as sterile.

Cardinal did not respond to questions about the adverse event reports.

China is the source of 45% of all the protective medical garments imported to this country, according to an analysis last month by the Peterson Institute for International Economics. Other countries where gowns for U.S. health care workers are manufactured include Mexico, Thailand, Cambodia, Honduras and the Dominican Republic, according to the nonprofit ECRI Institute in Plymouth Meeting, Pennsylvania.

Another major distributor of surgical gowns, Medline Industries Inc., declined to answer questions about where its gowns are made. Attempts to contact another supplier, Halyard, were unsuccessful.

At a health care conference last month, Halyard’s parent company reported making surgical gowns at a plant in San Pedro Sula, Honduras.

For Cardinal, the recall has been a costly blow to its bottom line and reputation. The company’s operating earnings declined 34% in the second quarter ending Dec. 31, in part due to a $96 million charge related to the recall.

“We don’t know how this could affect our business going forward, and we’re hoping that it doesn’t,” Cardinal’s Kaufman said in a conference call with investment analysts in February. “But we know that we have created some pain.”

ProPublica is an independent, non-profit newsroom that produces investigative journalism in the public interest.


Get the latest on healthcare leadership in your inbox.